Möglichkeiten der Rücklösung und Rückgewinnung von Phosphor und anderen Wertstoffen aus Ruhlebener Klärschlammasche durch Säuren, Basen und/oder Additiven

In this master thesis the redissolution and recovery of phosphorus (P) and other valuable materials from Ruhleben sewage sludge ash (R-SSA) with HCl and H2SO4 was investigated using experimental laboratory tests. The parameters acid amount, solid liquid ratio (s/l ratio) and reaction time were varied and their influence on the redissolution of Ca, P, Al, Fe and SO4 was measured. Results showed that HCl(37%) resolved 91 ± 4 % P with an acid amount of 4 mL on 5 g R-SSA, a s/l ratio of 1:20 (acid concentration 0.46 mol/L) and a reaction time of 60 min. H2SO4(30%) on the other hand resolved 89 ± 3 % P at 6 mL on 5 g R-SSA, a s/l ratio of 1:10 (acid concentration 0.6 mol/L) and a reaction time of 60 min. Ca and SO4 showed very good redissolution of up to 100 % with HCl. The Ca redissolution with H2SO4 is clearly below that of HCl and is 63%. Al resolved to a lesser extent and reaches 65% with H2SO4 and 53% with HCl. Fe shows the lowest redissolution of 14% with HCl and 12% with H2SO4. The H2SO4 leaching experiments also showed that it is possible to separate the gypsum from the R-SSA if the leaching liquid is separated from the R-SSA after short contact times with H2SO4. The contact time, the acid amount and the s/l ratio have a big impact on the precipitation. It was possible to recover 75% of the total amount of gypsum that can be precipitated from R-SSA. In addition to this, the gypsum-free leaching liquid was then added to the R-SSA again which had already been leached, in order to dissolve P. There was no loss of P redissolution when the gypsum was extracted. This approach could not be observed in any other study. Based on the results, a recovery of 2,114 ± 130 t P/a with HCl and 2062 ± 130 t P/a with H2SO4 are possible if an amount of 30,000 t R-SSA/a is treated, which are forecasted for Berlin in the future. Since the redissolution of 91 ± 4% P requires an acid amount of 946 kg HCl(37%)/t R-SSA, this would result in an absolute annual acid requirement of 28,380 t HCl(37%) for 30,000 t R-SSA/a. H2SO4 experiments showed that 725 kg H2SO4(90%)/t R-SSA would be required for 89 ± 3% P redissolution, resulting in an absolute acid requirement of 21,750 t H2SO4(90%). Since H2SO4 has a lower consumption due to the higher concentration, is the cheaper acid of the two and has the possibility of recovering gypsum, H2SO4 would be preferred for leaching R-SSA from an economic point of view. In addition, about 75% of the gypsum can be precipitated with H2SO4, which corresponds to a quantity of 255 kg of gypsum(dry)/t R-SSA. At 30,000 t R-SSA/a, this results in an annual amount of 6630 ± 51 t gypsum that can be recovered.

Möchten Sie die „{filename}“ {filesize} herunterladen?

Um unsere Webseite für Sie optimal zu gestalten und fortlaufend verbessern zu können, verwenden wir Cookies. Durch die weitere Nutzung der Webseite stimmen Sie der Verwendung von Cookies zu. Weitere Informationen zu Cookies erhalten Sie in unserer Datenschutzerklärung.